Emissions code
P0411: Secondary air system flow not right
How much to fix P0411? Typically $260–$1,100.
Wide range: this job varies a lot. Itemize your quote for a better answer.
How this range is built
| Part of the job | Low | High |
|---|---|---|
| Parts | $150 | $700 |
| Labor: 1 to 2.5 hours × $110 to $150 an hour | $110 | $375 |
| Fees: shop supplies, disposal, diagnostics | $0 | $25 |
| Total, rounded | $260 | $1,100 |
The hourly rate is the BLS Occupational Employment and Wage Statistics, May 2025 average pay for this trade in the US, $27.13 an hour, times 4 to 5.5 to cover what a shop bills (overhead, tools, insurance, profit). Parts are a band from budget aftermarket to the manufacturer part. Full method.
Not a repair shop, estimates only. Typical range, estimate. Not a quote. Your car, parts and shop change the number.
This is the range for the most common fix, secondary air injection (smog) pump replacement. Which repair your car needs depends on a proper diagnosis.
Some engines have a small pump that blows fresh air into the exhaust for about the first minute after a cold start, which helps burn leftover fuel while the converter warms up. The computer checked that air flow and the amount did not match what it expected.
- Safe to drive?
- Usually yes, for now
- Most common cause
- Failed air pump
This does not change how the car drives. You can keep driving, but the light stays on and the car will not pass an emissions check.
Get quotes from local shops
Got P0411? Tell us your ZIP and a shop near you can quote the repair. Free, takes a minute.
Fair Price is not a contractor or a repair shop. Who sees your request
What you may notice
- Check-engine light on
- Loud whine from the air pump at cold start
- Pump silent when it should run
Common causes, most likely first
- Failed air pump
- Stuck or leaking check valve
- Cracked or clogged air hose
- Failed air control valve or relay
Check this first
Listen for the pump at a cold start. It should whir for under a minute. Ask the shop whether the check valves and hoses were tested before the pump was replaced, since those are cheaper and often the actual fault.
Other repairs that sometimes fix P0411
| Repair | Typical range, US |
|---|---|
| Diagnostic scan (check engine light) | $55 to $250 |
Before you pay
- Ask the shop what test showed this part is the cause, not just that the code appeared.
- Ask for parts and labor listed separately, and for the hours.
- Ask for a written OK before any extra work. Many states require written authorization before repairs.
Got a quote already? Check it against the range. Want to see if your car has a recall tied to this problem? Check recalls by VIN.
Need to read a code yourself? OBD-II scanners on eBay (affiliate link, disclosure).
P0411 questions
Is the pump expensive?
On many cars it is one of the pricier emissions parts, so a careful diagnosis matters. Test the valves, hoses and relay first, and replace the pump only if those check out.
Why does it only run on cold start?
It helps burn leftover fuel in the exhaust while the converter is still warming up. After a minute or so, the converter takes over, and the pump is no longer needed.
Can water cause failure?
Yes. Water can get into the pump or its valves and corrode them, especially in places with heavy rain, road salt or deep puddles. Hot exhaust can also crack the check valve.
How much does it cost to fix P0411?
The most common fix, secondary air injection (smog) pump replacement, has a typical range of $260 to $1,100 across the US. It is an estimate built from parts prices and local labor wages, not a quote. Your car and shop change it.
Typical range in 10 metro areas
Only the labor rate changes between cities. Same parts, same hours.
| Area | Typical range, estimate |
|---|---|
| Boston area, Massachusetts | $270 to $1,175 |
| New York City area | $270 to $1,150 |
| Los Angeles area, California | $270 to $1,150 |
| Chicago area, Illinois | $260 to $1,125 |
| Houston area, Texas | $250 to $1,100 |
| Dallas-Fort Worth area, Texas | $250 to $1,100 |
| Phoenix area, Arizona | $260 to $1,100 |
| Atlanta area, Georgia | $260 to $1,125 |
| Miami area, Florida | $250 to $1,100 |
| Seattle area, Washington | $270 to $1,150 |
Related codes
More emissions codes
Code meaning written in our own words. Some codes mean different things on different makes, so check your scan tool or manual. Not a repair shop, estimates only.